福建中立恒自动化设备有限公司

1．输入/输出单元

输入/输出单元通常也称I/O单元或I/O模块，是PLC与工业生产现场之间的连接部件。

PLC通过输入接口可以检测被控对象的各种数据，以这些数据作为PLC对被控制对象进行控制的依据；同时PLC又通过输出接口将处理结果送给被控制对象，以实现控制目的。

由于外部输入设备和输出设备所需的信号电平是多种多样的，而PLC内部CPU的处理的信息只能是标准电平，所以I/O接口要实现这种转换。

I/O接口一般都具有光电隔离和滤波功能，以提高PLC的抗干扰能力。另外，I/O接口上通常还有状态指示，工作状况直观，便于维护。

PLC提供了多种操作电平和驱动能力的I/O接口，有各种各样功能的I/O接口供用户选用。I/O接口的主要类型有：数字量（开关量）输入、数字量（开关量）输出、模拟量输入、模拟量输出等。

常用的开关量输入接口按其使用的电源不同有三种类型：直流输入接口、交流输入接口和交/直流输入接口。

常用的开关量输出接口按输出开关器件不同有三种类型：是继电器输出、晶体管输出和双向晶闸管输出。

继电器输出接口可驱动交流或直流负载，但其响应时间长，动作频率低；而晶体管输出和双向晶闸管输出接口的响应速度快，动作频率高，但前者只能用于驱动直流负载，后者只能用于交流负载。

PLC的I/O接口所能接受的输入信号个数和输出信号个数称为PLC输入/输出（I/O）点数。I/O点数是选择PLC的重要依据之一。当系统的I/O点数不够时，可通过PLC的I/O扩展接口对系统进行扩展。

2．通信接口

PLC配有各种通信接口，这些通信接口一般都带有通信处理器。

PLC通过这些通信接口可与监视器、打印机、其它PLC、计算机等设备实现通信。

PLC与打印机连接，可将过程信息、系统参数等输出打印；与监视器连接，可将控制过程图像显示出来；与其它PLC连接，可组成多机系统或连成网络，实现更大规模控制。

与计算机连接，可组成多级分布式控制系统，实现控制与管理相结合。远程I/O系统也必须配备相应的通信接口模块。

3．智能接口模块

智能接口模块是一独立的计算机系统，它有自己的CPU、系统程序、存储器以及与PLC系统总线相连的接口。

它作为PLC系统的一个模块，通过总线与PLC相连，进行数据交换，并在PLC的协调管理下独立地进行工作。

PLC的智能接口模块种类很多，如：高速计数模块、闭环控制模块、运动控制模块、中断控制模块等。

142-0701// AMAT APPLIED 0150-00901 APPLIED MATRIALS COMPONENTS

142-0701// AMAT APPLIED 0150-09517 CABLE ASSY,CAP MONO/PROC GAS I

142-0701// AMAT APPLIED 0150-10307 APPLIED MATRIALS COMPONENTS

142-0701// AMAT APPLIED 0150-15039 CABLE, JUMPER, O/L TO NEUTRAL

142-0701// AMAT APPLIED 0150-21192 APPLIED MATRIALS COMPONENTS

142-0701// AMAT APPLIED 0150-22528 C/A, DEVICENET IO TO BULKHEAD

142-0701// AMAT APPLIED 0240-01157 LEVEL TWO SPARES KIT, GENERIC

142-0702// AMAT APPLIED 0150-00267 APPLIED MATRIALS COMPONENTS

142-0702// AMAT APPLIED 0150-09010 ASSY, FLAT CABLE 34 POS

142-0702// AMAT APPLIED 0150-09049 ASSY CABLE REMOTE DIGIT

142-0702// AMAT APPLIED 0150-09236 CABLE ASY FLOPPY DISK DR

142-0702// AMAT APPLIED 0150-20038 CABLE ASSY, REMOTE AI/O CONTRO

142-0702// AMAT APPLIED 0150-20080 CABLE ASSY PUMP FRAME DIST

142-0703// AMAT APPLIED 0140-00507 APPLIED MATRIALS COMPONENTS

142-0703// AMAT APPLIED 0140-38196 HARN. ASSY,BARATRON CABLE OVERPRESS,TANT

342-0101 AMAT APPLIED 0020-22839 PIN, PRECLEAN LIFT

321-0501 USHIO 120V-500W EHD HALOGEN LAMP

142-0703// AMAT APPLIED 0150-05397 CABLE ASSY, RESET SWITCH, LIGHT CURTAIN

142-0703// AMAT APPLIED 0150-09368 ASSY CABLE FEEDER WIRE K3-4 TO

142-0703// AMAT APPLIED 0150-09422 CABLE ASSY,INTERLOCK SYS

142-0703// AMAT APPLIED 0150-70002 CABLE FLAT ASSY SCSI 50P EXTEN

352-0403// AMAT APPLIED 0020-91466 SCREW-VAC CAP HD M8X30 SST

352-0403// AMAT APPLIED 0021-10024 GAS INSERT SCREW, SGD, POLY MX

352-0403 AMAT APPLIED 0021-10466 COVER,RF OUTPUT,COOL MATCH

324-0101// AMAT APPLIED 0190-02852 SCREW, M6X20 P5000 ZA MK-II

 M5 ALUM

324-0101// AMAT APPLIED 3690-02572 3880-01007 SCREW MACH BDG

324-0101// AMAT APPLIED 3690-03624 3880 01045 SCR CAP SKT HD

123-0302// AMAT APPLIED 0020-21833 VIEWPORT, DETECTOR

342-0303// AMAT APPLIED 0021-19364 BRACKET, HIGH AIR FLOW VALVE, SLOTTED

342-0303// AMAT APPLIED 0021-19366 BRACKET, MOTING, BLOCK VALVE, 300MM

346-0302// AMAT APPLIED 0021-10973 BRKT, MONOBLOCK VALVE

346-0302// AMAT APPLIED 0040-75075 CLAMP AC CONDUIT CENT, CHMBR FAC

342-0101// AMAT APPLIED 0020-09912 LIFTING PIN, SPUTTER.

141-0303// AMAT APPLIED 3860-01467 TBG PLSTC 5/32OD 3/32ID POLYURETHANE

141-0303// AMAT APPLIED 3860-01469 TBGPLSTC 5/32OD 3/32ID POLYU

347-0201// AMAT APPLIED 0021-04652 LIFT COVER B101, BLT, 101, HTESC

350-0202// AMAT APPLIED 0021-22229 CLAMP TOP CABLE HOLDER SOURCE GNDS

350-0202// AMAT APPLIED 0021-22230 CLAMP BOTTOM CABLE HOLDER SOURCE GN

142-0502// AMAT APPLIED 0150-09258 CABLE ASSY,MFC 42 LONG

142-0502// AMAT APPLIED 0150-10016 CABLE ASSY OZONATOR, SEGMENT 4

142-0502// AMAT APPLIED 0150-35286 CABLE ASSY CHAMBER PNEUMATICS

142-0502// AMAT APPLIED 0150-93070 C.A. E.M.C. CAP ASSY

176-0504// AMAT APPLIED 3300-01513 FTGTBG PLUG 1/4VCR-M 9/16-18THD 5/8HEX

 1-1/4 304/316 SST

 7/8 304/316SST SLV

 1-3/8 304/316 SST

324-0102// AMAT APPLIED 0020-07272 STUD, CRYO/GATE VALVE W/HEX SOCKET FOR W

143-0503 AMAT APPLIED 0150-20143 WIRE, JUMPER 4PIN CONN, GEN RACK EMO

342-0201// AMAT APPLIED 3320-01057 GSKT KIT NW-40 MDC

341-0201// AMAT APPLIED 0020-20626 BLOCK, MOTING, SHUT-OFF VALV

352-0103// AMAT APPLIED 0020-29788 APPLIED MATRIALS COMPONENTS

352-0103// AMAT APPLIED 0021-76476 APPLIED MATRIALS COMPONENTS

341-0301 AMAT APPLIED 0020-44403 APPLIED MATRIALS COMPONENTS

341-0301 AMAT APPLIED 0020-44405 APPLIED MATRIALS COMPONENTS

341-0301 AMAT APPLIED 0020-44406 APPLIED MATRIALS COMPONENTS

341-0301 AMAT APPLIED 0020-45649 APPLIED MATRIALS COMPONENTS

 3/8 LG SST

321-0301 AMAT APPLIED 3690-02568 SCR CAP SKT HD 2-56X1/2L HEX SKT

321-0402 AMAT APPLIED 3320-02242 GSKT 1.33 CFF OFHC Cu

141-0502// AMAT APPLIED 0150-20664 CABLE ASSY WTR LEAK TRAYTRAY

141-0502// AMAT APPLIED 0150-35250 C/A CENTERFINDER EXT

341-0301 AMAT APPLIED 0020-46949 APPLIED MATRIALS COMPONENTS

341-0301 AMAT APPLIED 0020-48652 APPLIED MATRIALS COMPONENTS

323-0401 AMAT APPLIED 0090-20016 DEGAS COVER OPEN SWITCH

401-0201// KOINO KTM-3M TIMING RELAY

143-0203// AMAT APPLIED 0150-09811 APPLIED MATRIALS COMPONENTS

346-0201// AMAT APPLIED 0020-09817 BRACKET LATCH

323-0301 AMAT APPLIED 0020-20126 STAND-OFF, CERAMIC DC BIAS

401-0201// NAIS AY33002 PA1A-PS PA1A-24V APA3312

114-0401// AMAT APPLIED 0020-09807 EDGE PLATE FIXED PANEL

344-0502// AMAT APPLIED 0090-00316 APPLIED MATRIALS COMPONENTS

344-0502// AMAT APPLIED 0090-09063 CABLE STRAIN RELEASING FINGER

348-0201// AMAT APPLIED 0690-01797 CLAMP BHD K100-BC 1.23 ID .39THK AL NO H

0010-52219 / HEATER ASSY WITH DYLYN MCA GROOVED / APPLIED MATERIALS AMAT

0010-42641-01 /42216001 ASSY FAN COOLED RESONATOR 300MM/ APPLIED MATERIALS AMAT

0010-07815 /ASSY 300MM SLT ESC WITH CENTER TAP META 0020-08825/ APPLIED MATERIAL

0240-81550, 0041-36356 / POLISHER,TITAN HEAD,6 ZONE300MM CMP 0041-30053 / AMAT

9090-00801 A1031250 / PRE ACCEL POWER SUPPLY QUANTUM 3 / AMAT HITEK POWER

0100-A0020 /ADVANCE SP CARD ASSY /APPLIED MATERIALS

50415500210 /CPU ASSY -9300, 70515550000, 09JI036, PS100 REV /APPLIED MATERIALS

UO2800PMCA / MIKRO SONIC GENERATOR MASTER SLAVE SET TEL EXPEDIUS / HITACHI

E11102760 / VARIAN LENS ASSY, HIGH ENERGY / VARIAN

0040-62258 / CHAMBER, BODY, 300MM, SWLL B / APPLIED MATERIALS AMAT

0010-53085-01 / HEATER PEDESTAL 200MM W/ESC REFURB ESIP-REPAIR 10-24456 / AMAT

RASM0208 / ASSY-PROCESS MANIFOLD 150MM -FRONT ASM E2  E2000 REACTOR / ASML

5187-026732-13 /ASSY,BTM FLANGE,REACTOR..PE A 8PORT / TOKYO ELECTRON TEL

0040-07033 /MC, HA-12, CERAMIC HEATER, 300MM PRODUC / APPLIED MATERIALS AMAT

63-272856-00 / FRU ARM MAG7 LEAPFROG WTS-HV 1080 EXT / LAM RESEARCH

0032129-000 / PSF REAR CHANNEL ASSEMBLY W/ EXCHANGE / KLA TENCOR CORPORATION

3385-000865-13 / CHUCK TOP H C150C CU STANDARD P12 CHUCK / TOKYO ELECTRON

AX8407A-11 / AX8400,0190-26924,OZGAS GENERATOR,5 - 40 SLM / MKS

0010-16858-001 / PEDESTAL, 300MM SDMCA FDR SLT ESC ASSY 0010-14204-001 / AMAT

0040-51612 /HEATER MC CERAMIC NGK PRODUCER 200MM 0040-39947/ APPLIED MATERIALS

6-0002-1398-SP / ABM-407C-1-S1CE-S293 ROBOT ECO-28318 / BROOKS AUTOMATION

0041-34310 0010-45680/CHAMBER HEATER ASSY HA - 12 WC SR SEQUOIA/AMAT

220550109 / LENS MODULE / APPLIED MATERIALS AMAT

50516000100 / AMAT G2 OCTANE ASSY SGI OCTANE MODEL CMN 015 / APPLIED MATERIALS

839-019080-608 / ESC, TABLE 4-Z300MM NO EPOXY, 715-073734-002G/ LAM RESEA

0010-27432 / HEATER PEDESTAL 0040-70176 / APPLIED MATERIALS AMAT

GW2502MA-B1C001-L3 / GMW-25 RF GENERATOR 2500W 660-110685-112 REV. B / ENI

0040-84820/AMAT ENDURA BATCH LOAD LOCK INDEXER WITH MOTOR ASSY./APPLIED MATERIAL

FNQ-T13-000075H / NIKKO TI SIP TARGET, AMAT 0190-02397 / NIKKO METALS

Z TRANSPORT ASSY PNP / DELTA

839-019090-611 / ESC, TABLE 4-Z300MM NO EPOXY, 715-073734-002G / LAM

2304535-00 /LANPOWER SIPC-B 6180 PC PIII 1.26 GHZ 512 MB RAID 3HD 9 ISA4 PCI/SEZ

MKS-050B04D-PS-V / NIHON KOSHUHA PWR GENERATOR MKS-050B-PS / TEL 3Z87-002704-14

BM44620 / STOCKER - I/O-2X2 / BROOKS AUTOMATION

MWH-100-03 / HF MATCHING NETWORK 13.56MHZ ENI W/WTR FTG 02-352391-00 / MKS

GHW50Z-09030 / GHW50Z GENESIS RF GENERATOR AMAT 0190-39519 2500W / ENI

3155162-023/RF MATCH 13.56MHZ 10KW AUTOMATCH C3SPD R27-293459-00/ADVANCED ENERGY

E11076241 /VARIAN LOWER 70 CONTROL  MULTI BANK, VIISTA VISION / VARIAN

30712403000 / AMAT OPAL CDM3B ASSY / APPLIED MATERIALS

0010-05478 / ASSY, MONOCHROMATOR CONTROL , 300MM, / APPLIED MATERIALS AMAT

BM44421 / STOCKER - I/O - 4X4 - OUTPUT AD 44421 / BROOKS AUTOMATION

15-397695-00/DARK SPACE RING 300MM, ANGLED ARC SPRAY, PVD 02-380622-00/NOVELLUS

0090-90215 / WCHAS WRD INVERTER FOCUS / APPLIED MATERIALS AMAT

0010-03843 /NGK INSOLATOR AMAT CERAMIC HEATER WITH CERT / APPLIED MATERIALS CORP

21016404077 /NEAT STAGE CONTROLLER /APPLIED MATERIALS AMAT

0010-15210, 0010-34561 200MM PCIIE, MCA GRV .1MM DEEP PUCK HV /AMAT

A41943012 / DRY VACUUM PUMP, EPX180LE, 200-208V, 50-60HZ, 16A / EDWARDS

0190-04681 / ROTARY ION AND SLIP RING ASSY 300MM / APPLIED MATERIALS AMAT

A45188 / LOW K FLOWFILL MK3B RF  ASSY WITH A45347 LF RF  ASSY / TRIKON

A45347 / LOWK FF MK3B LF ALTERNATE PART A45188 /TRIKON/SPTS TECHNOLOGIES

0010-03840 / CER HTR ASSY, 200MM PRODUCER / APPLIED MATERIALS AMAT

880-05229-000 / E-G KLA 8100 8100XP 8100E 880-50510-000 WITH EXCHANGE / KLA

715-250411-002 / ESC CHUCK 6 HOLE / LAM RESEARCH CORPORATION

0036451-000 / TURRET  COLECTION, FOLD, FOCUS MIRR 42-JJ978-A / KLA TENCOR

45-110-2-0767-1 / EMS POWER SUPPLY 7A1 BEAM FILTER MAGNET SUPPLY / EMS VARIAN

740-12852-000 / Z-STAGE, 300MM, 8450, 740-12986-000, 740-12985-000 / KLA TENCOR